| Summary: | Woody breast (WB) myopathy is a quality defect, afflicting a large portion of commercial broilers to some degree. The WB myopathy is commonly attributed to rapid bird growth and characterized by excessive fibrosis within the pectoralis major, which is thought to cause the palpably hardened texture observed in the afflicted breast meat. These phenotypically tough breast fillets are not marketed for traditional intact muscle products owing to poor quality and eating experience. Potential avenues for these afflicted breast fillets include their use in formulation of fresh and cooked sausages. Two degrees of WB fillets (moderate and severe) were used as a replacement for normal (unafflicted) breast fillet meat at levels of 25, 50, and 100%, in a sausage formulation with 1.5% salt and 15% chicken fat. All 6 treatments were compared with a control formulation (100% normal breast meat) and analyzed for texture profile, cook loss, color, and proximate composition. Moisture and fat content for all formulations were similar (P = 0.95 and P = 0.33, respectively), but with increase in the inclusion rate of WB meat, lower protein content (P < 0.01) was observed. Raw sausage color indicated a lighter (P < 0.05) color for the control sausage (100% normal) than with both 100% moderate and 100% severe formulations. Similarly, sausages containing 100% severe WB meat were the darkest (L∗; P < 0.05), but they were similar to sausages containing 100% moderate (P > 0.05) WB meat. Texture profile analysis indicated a decrease in hardness, cohesiveness, and springiness with use of 100% severe WB meat, while inclusion of lower proportions of severe WB meat resulted in similar textural characteristics. These results indicate the possibility of using WB fillet meat in a sausage formulation with minimal impact on sausage texture profiles.
|
|---|