The study of pressure fluctuations in the pressure line of the pump and of the efficiency of the vibration absorbers
The article presents the results of experimental studies of pressure fluctuations in the pipes of piston pumps. The relevance of these studies is due to the need to reduce the pressure fluctuations that create a positive displacement pumps, due to their negative impact not only on the reliability of...
| Main Authors: | , |
|---|---|
| Format: | Article |
| Language: | English |
| Published: |
Odessa National Polytechnic University
2016-12-01
|
| Series: | Trudy Odesskogo Politehničeskogo Universiteta |
| Subjects: | |
| Online Access: | http://pratsi.opu.ua/articles/show/8583 |
| _version_ | 1811193381992267776 |
|---|---|
| author | O.V. Korolyov Zhou Huiyu |
| author_facet | O.V. Korolyov Zhou Huiyu |
| author_sort | O.V. Korolyov |
| collection | DOAJ |
| description | The article presents the results of experimental studies of pressure fluctuations in the pipes of piston pumps. The relevance of these studies is due to the need to reduce the pressure fluctuations that create a positive displacement pumps, due to their negative impact not only on the reliability of the pump, but the accuracy of flow measurement and pressure of the medium supplied to such pumps. Aim: The aim of this study was to investigate the hydraulic characteristics of pulsating flows in pressure lines piston pumps of liquefied gas, as well as the study of the effectiveness of the dampers of pressure pulsations and conformity of their parameters to the calculation. Materials and Methods: As a drive used the piston pumps − single-line and trilinear. In the tests recorded pressure fluctuations in the pressure line. For this purpose the low-inertia pressure sensors 15.0 MPa working complete with strain test station, which allows registering the pressure fluctuations at frequencies up to 10 kHz. Strain test station output signal fed to the input of the oscilloscope operating in memory mode. In all tests the pressure sensor is mounted at three points - after the piston group on the pressure line before the damping device and after it. In the experiment, three different damper was used - two new, designed by the author's method and one regular damper, which are equipped with serial piston pumps. Dampers installed vertically, the flow entering to the lower cap, and an output through the side surface. Results: The experimental results confirmed the general position of the greater efficiency of complex composite filters and the correctness of chosen method of their calculation, proposed earlier by the authors. In particular, the actual level of weakening of pressure fluctuations on developed damper with a high degree coincided with the calculated results. |
| first_indexed | 2024-04-12T00:07:24Z |
| format | Article |
| id | doaj.art-a9ee7205253e4c20a95022781c50f08a |
| institution | Directory Open Access Journal |
| issn | 2076-2429 2223-3814 |
| language | English |
| last_indexed | 2024-04-12T00:07:24Z |
| publishDate | 2016-12-01 |
| publisher | Odessa National Polytechnic University |
| record_format | Article |
| series | Trudy Odesskogo Politehničeskogo Universiteta |
| spelling | doaj.art-a9ee7205253e4c20a95022781c50f08a2022-12-22T03:56:03ZengOdessa National Polytechnic UniversityTrudy Odesskogo Politehničeskogo Universiteta2076-24292223-38142016-12-0120163414610.15276/opu.3.50.2016.08The study of pressure fluctuations in the pressure line of the pump and of the efficiency of the vibration absorbersO.V. Korolyov0Zhou Huiyu1Odessa National Polytechnic UniversityOdessa National Polytechnic UniversityThe article presents the results of experimental studies of pressure fluctuations in the pipes of piston pumps. The relevance of these studies is due to the need to reduce the pressure fluctuations that create a positive displacement pumps, due to their negative impact not only on the reliability of the pump, but the accuracy of flow measurement and pressure of the medium supplied to such pumps. Aim: The aim of this study was to investigate the hydraulic characteristics of pulsating flows in pressure lines piston pumps of liquefied gas, as well as the study of the effectiveness of the dampers of pressure pulsations and conformity of their parameters to the calculation. Materials and Methods: As a drive used the piston pumps − single-line and trilinear. In the tests recorded pressure fluctuations in the pressure line. For this purpose the low-inertia pressure sensors 15.0 MPa working complete with strain test station, which allows registering the pressure fluctuations at frequencies up to 10 kHz. Strain test station output signal fed to the input of the oscilloscope operating in memory mode. In all tests the pressure sensor is mounted at three points - after the piston group on the pressure line before the damping device and after it. In the experiment, three different damper was used - two new, designed by the author's method and one regular damper, which are equipped with serial piston pumps. Dampers installed vertically, the flow entering to the lower cap, and an output through the side surface. Results: The experimental results confirmed the general position of the greater efficiency of complex composite filters and the correctness of chosen method of their calculation, proposed earlier by the authors. In particular, the actual level of weakening of pressure fluctuations on developed damper with a high degree coincided with the calculated results.http://pratsi.opu.ua/articles/show/8583piston pumpdamperpressure fluctuations |
| spellingShingle | O.V. Korolyov Zhou Huiyu The study of pressure fluctuations in the pressure line of the pump and of the efficiency of the vibration absorbers Trudy Odesskogo Politehničeskogo Universiteta piston pump damper pressure fluctuations |
| title | The study of pressure fluctuations in the pressure line of the pump and of the efficiency of the vibration absorbers |
| title_full | The study of pressure fluctuations in the pressure line of the pump and of the efficiency of the vibration absorbers |
| title_fullStr | The study of pressure fluctuations in the pressure line of the pump and of the efficiency of the vibration absorbers |
| title_full_unstemmed | The study of pressure fluctuations in the pressure line of the pump and of the efficiency of the vibration absorbers |
| title_short | The study of pressure fluctuations in the pressure line of the pump and of the efficiency of the vibration absorbers |
| title_sort | study of pressure fluctuations in the pressure line of the pump and of the efficiency of the vibration absorbers |
| topic | piston pump damper pressure fluctuations |
| url | http://pratsi.opu.ua/articles/show/8583 |
| work_keys_str_mv | AT ovkorolyov thestudyofpressurefluctuationsinthepressurelineofthepumpandoftheefficiencyofthevibrationabsorbers AT zhouhuiyu thestudyofpressurefluctuationsinthepressurelineofthepumpandoftheefficiencyofthevibrationabsorbers AT ovkorolyov studyofpressurefluctuationsinthepressurelineofthepumpandoftheefficiencyofthevibrationabsorbers AT zhouhuiyu studyofpressurefluctuationsinthepressurelineofthepumpandoftheefficiencyofthevibrationabsorbers |